廚房排煙管道是怎么設計你知道嗎？

發布人：http://m.hwzxw.net   發布時間：2018-12-20 10:59:35

關于廚房排煙管道設計和裝置不合理有哪些原因?下面由排煙管道的人員介紹一下：

What are the reasons for the unreasonable design and installation of kitchen smoke exhaust pipes? The following is an introduction by the professional staff of smoke exhaust pipes:

一、主排煙管道通風面積不行

1. Ventilation area of main exhaust pipe is not good

依據工程經驗，排煙主管道內風速不能超過15m/s，否則在運轉一個時期以后很簡單形成排煙系統不曉暢。在油煙凈化器的運轉實踐中，大部分案例都是因排煙管道通風面積缺乏引起的不曉暢，管道內氣體的流速都在15m/s以上。

According to engineering experience, the wind speed in the main smoke exhaust pipe should not exceed 15 m/s. Otherwise, after a period of operation, the smoke exhaust system can not be smoothly formed. In the operation practice of the oil fume purifier, most cases are caused by the lack of ventilation area of the exhaust pipe, and the flow rate of the gas in the pipe is above 15m/s.

二、管道截面積變小

II. Reduction of Pipeline Section Area

排煙管道因?yàn)橐┻^修建梁而使管道通風截面積變小，截面上阻力增加，形成氣流不曉暢。

Because the smoke exhaust pipeline passes through the building beam, the ventilation cross-section area of the pipeline becomes smaller, the resistance on the cross-section increases, and the airflow is not clear.

三、排管道使用后積累物堆積

3. Accumulate accumulation after use of drainage pipeline

排煙管道在穿過修建梁或躲避其它設備管道時，排煙管道中的一段會低于整體排煙管道平面，在使用一段時間后，因?yàn)橛退旌衔飼?huì)積累在較低的那段排煙管道中，直接影響排煙曉暢。

When the smoke exhaust pipeline passes through the building beam or avoids other equipment pipelines, one section of the smoke exhaust pipeline will be lower than the overall level of the smoke exhaust pipeline. After a period of use, because the oil-water mixture will accumulate in the lower section of the smoke exhaust pipeline, which directly affects the smoothness of smoke exhaust.

四、低層排煙不順利

4. Smoke exhaust at low level is not smooth

不同樓層的廚房油煙通過同一主管道排出，離出口近的樓層廚房排煙效果較好，而較低樓層的廚房排煙不曉暢。

The kitchen fumes of different floors are discharged through the same main pipe. The kitchen fumes of the floors near the exit are better, while the kitchen fumes of the lower floors are not smoothly exhausted.

五、主張配備排煙風機

Fifth, advocating the equipping of smoke exhaust fans

關于油煙較大的廚房，主張還配備一個排煙風機。常用的排煙風機有軸流風機、風機箱和離心風機3種。

As for kitchens with bigger oil fumes, it is advocated that a smoke exhaust fan should also be equipped. The common smoke exhaust fans are axial fan, fan box and centrifugal fan.

如果需要排煙管道裝置的話，可以聯絡咱們，咱們會為你效勞的!

If you need a smoke exhaust pipe, you can contact us, we will be at your service!